Document Outline

• © 2010 Invacare Corporation. All rights reserved. Republication, duplication or modification in whole or in part is prohibited without prior written permission from Invacare. Trademarks are identified by ™ and ®. All trademarks are owned by or li...
• 1 General 6
  • Symbols 6
  • Limited Warranty 7
• 2 Overview 8
  • Label Location 8
  • Component Identification 9
  • Typical Product Parameters 10
• 3 Safety 11
  • General Guidelines 11
  • Safety/Handling of Wheelchairs 17
• 4 Safety Inspection/Troubleshooting. 25
  • Safety Inspection Checklists 25
  • Troubleshooting 27
  • Maintenance 28
• 5 Front Riggings 31
  • Installing/Removing Swingaway Footrest Assembly 31
  • Swingaway Footrest Height Adjustment 32
  • Installing/Removing Elevating Legrest Assembly 32
  • Adjusting Elevating Legrest Assembly 33
  • Raising/Lowering Elevating Legrest Assembly 34
  • Installing Calf Strap 35
  • Heel Loop Replacement 36
• 6 Arms 37
  • Adjusting Armrest Height 37
  • Replacing Desk/Full Length Armrest Pad 39
  • Removing or Replacing Armrest 39
• 7 Seat and Back 41
  • Replacing Seat Upholstery 41
  • Replacing Back Upholstery 42
  • Adjusting Back Height 42
  • Adjusting Seat Depth 43
  • Adjusting Seat Width 43
• 8 Rear Wheels 44
  • Removing/Installing Rear Wheels 44
• 9 Front Casters 45
  • Installing/Replacing Six or Eight-inch Front Casters and Forks 45
  • Front Caster Mounting Adjustments 46
• 10 Anti-tippers/Wheel Locks 47
  • Installing Anti-Tippers 47
  • Using/Adjusting Wheel Locks 49
• 11 Options 52
  • Installing Crutch and Cane Carrier 52
  • Installing Seat Positioning Strap 53
  • Wheel Lock Extension Handle 54
  • Installing/Removing Solid Seat Insert 55
  • Installing/Removing Solid Back Insert 55
  • Installing O2 Holder/Telescoping I.V. Rod with O2 Holder 56
  • Installing Telescoping I.V. Rod 57
  • Installing/Removing Push Bar 61
  • Installing/Removing One-Piece Footboard 62
  • One Piece Footboard Height Adjustment 65
• 1 General
  • 1.1 Symbols
    • Warnings
      • Signal words are used in this manual and apply to hazards or unsafe practices which could result in personal injury or property damage. See the information below for definitions of the signal words.
        • m
    • danger
      • Danger indicates an imminently hazardous situation which, if not avoided, will result in death or serious injury.
        • m
    • Warning
      • Warning indicates a potentially hazardous situation which, if not avoided, could result in death or serious injury.
        • m
    • caution
      • Caution indicates a potentially hazardous situation which, if not avoided, may result in property damage or minor injury or both.
        • !
    • important
      • Indicates a hazardous situation that could result in damage to property if it is not avoided.
• i
  • Gives useful tips, recommendations and information for efficient, trouble-free use.
  • 1.2 Limited Warranty
    • PLEASE NOTE: THE WARRANTY BELOW HAS BEEN DRAFTED TO COMPLY WITH FEDERAL LAW APPLICABLE TO PRODUCTS MANUFACTURED AFTER JULY 4, 1975.
    • This warranty is extended only to the original purchaser who purchases this product when new and unused from Invacare or a dealer. This warranty is not extended to any other person or entity and is not transferable or assignable to any subsequent pur...
    • This warranty gives you specific legal rights and you may also have other legal rights which vary from state to state.
    • Invacare warrants the side frames and cross members of this product when purchased new and unused to be free from defects in materials and workmanship for a period of three years from the date of purchase from Invacare or a dealer, with a copy of the...
    • For warranty service, please contact the dealer from whom you purchased your Invacare product. In the event you do not receive satisfactory warranty service, please write directly to Invacare at the address at the bottom of this page. Provide dealer...
    • Limitations and Exclusions: The foregoing warranty shall not apply to serial numbered products if the serial number has been removed or defaced, products subjected to negligence, accident, improper operation, maintenance or storage, products modified...
    • THE FOREGOING EXPRESS WARRANTY IS EXCLUSIVE AND IN LIEU OF ANY OTHER WARRANTIES WHATSOEVER, WHETHER EXPRESS OR IMPLIED, INCLUDING THE IMPLIED WARRANTIES OF MERCHANTABILITY AND FITNESS FOR A PARTICULAR PURPOSE, AND THE SOLE REMEDY FOR VIOLATIONS OF AN...
    • Some states do not allow the exclusion or limitation of incidental or consequential damage, or limitation of how long an implied warranty lasts, so the above exclusion and limitation may not be applicable.
    • THIS WARRANTY SHALL BE EXTENDED TO COMPLY WITH STATE/PROVINCIAL LAWS AND REQUIREMENTS.
• i
  • 1079203 located on seat rail next to the middle H-block.
  • 2 Overview
    • 2.1 Label Location
    • 2.2 Component Identification
  • Seat Upholstery
    • 2.3 Typical Product Parameters
      • seat width
      • handrims
      • Overall width
      • wheel locks
      • seat depth
      • caster size
      • overall depth (with riggings)
        • upholstery
      • seat-to-floor
      • frame colors
      • back style
      • weight*
      • back height
      • shipping weight**
      • (Approx.)
      • arm styles
        • Weight limit
      • Front riggings
• i
  • * Chair only without footrest (30-inches wide X 20-inches deep)
  • **Chair with footrest (30-inches wide X 20-inches deep)
    • rear axle
    • Rear wheels
• i
  • When changes to the left hand column occur, follow across the chart and refer to the • procedure to maintain the proper stability, safety and handling of the wheelchair.
  • 3 Safety
    • The safety section contains important information for the safe operation and use of this product.
      • m
    • Warning
      • After any adjustments, repair or service and before use, make sure all attaching hardware is tightened securely - otherwise, injury or damage may result.
    • 3.1 General Guidelines
      • m
      • Warning
        • Do not use this product or any available optional equipment without first completely reading and understanding these instructions and any additional instructional material such as owner’s manual/9000-topaz?page=11">m
    • accessories Warnings
      • Invacare products are specifically designed and manufactured for use in conjunction with Invacare accessories. Accessories designed by other manufacturers have not been tested by Invacare and are not recommended for use with Invacare products.
        • !
    • notice
      • The information contained in this document is subject to change without notice.
      • Check all parts for shipping damage and test before using. In case of damage, do NOT use. Contact Invacare/Carrier for further instruction.
      • Anti-Tippers
        • m
    • Warning
      • ALWAYS use anti-tippers. When outdoors on wet, soft ground or on gravel surfaces, anti-tippers may not provide the same level of protection against tipover. Extra caution must be observed when traversing such surfaces.Inasmuch as anti-tippers are an ...
    • General Warnings
      • m
    • Warning
      • To determine and establish your particular safety limits, practice bending, reaching and transferring activities in several combinations in the presence of a qualified healthcare professional before attempting active use of the wheelchair.
      • Avoid storing or using the wheelchair near open flame or combustible products. Serious injury or damage to property may result.
      • DO NOT stand on the frame of the wheelchair.
      • DO NOT use the footplate as a platform. When getting in or out of the wheelchair, make sure that the footplates are in the upward position.
      • Always use the handrims for self-propulsion. Inasmuch as the handrims are an option on this wheelchair (you may order with or without the handrims), Invacare strongly recommends ordering the handrims as an additional safeguard for the wheelchair user.
      • Invacare recommends that a non-folding device be installed to keep the wheelchair from being folded when left unoccupied in a public place.
      • DO NOT operate on roads, streets or highways.
      • DO NOT allow children to play on or operate the wheelchair.
      • DO NOT operate on soft surfaces such as sand, grass, or gravel.
    • Hand Grips
      • m
    • Warning
      • ALWAYS check hand grips for looseness before using the wheelchair. If loose and/or worn, replace IMMEDIATELY.
      • When cleaning rear cane or hand grip areas use only a clean towel lightly dampened with cool water. Verify that grips are dry prior to use. Use of soap or ammonia based cleaning solutions will result in the hand grips sliding off the cane assembly. F...
      • If the wheelchair is exposed to extreme temperature (above 100°F or below 32°F), high humidity and/or becomes wet, prior to use, ensure that the handgrips DO NOT twist on the handle. Otherwise, damage or injury may occur.
    • Information for Healthcare Professionals/Assistants
      • m
    • Warning
      • When assistance to the wheelchair user is required, remember to use good body mechanics. Keep your back straight and bend your knees whenever tipping the wheelchair or traversing curbs, or other impediments.
      • When learning a new assistance technique, have an experienced assistant help you before attempting it alone.
    • Lifting
      • m
    • Warning
      • DO NOT attempt to lift the wheelchair by any removable (detachable) parts. Lifting by means of any removable (detachable) parts of the wheelchair may result in injury to the user or damage to the wheelchair.
    • Ramps, Slopes, Inclines, and Obstacles
      • m
    • Warning
      • DO NOT traverse, climb or go down ramps or slopes greater than 4°.
      • DO NOT attempt to move up or down an incline with a water, ice or oil film.
      • DO NOT attempt to ride over curbs or obstacles. Doing so may cause your wheelchair to tip over and cause bodily harm to you or damage to the wheelchair
      • NEVER leave an unoccupied wheelchair on an incline.
      • DO NOT attempt to stop the wheelchair while on a sloped surface.
    • Repair and Service Information
      • m
    • Warning
      • Unless otherwise noted, all service and adjustment should be performed while the wheelchair is unoccupied.
    • Seat Positioning Straps
      • m
    • Warning
      • ALWAYS wear your seat positioning strap. Inasmuch as the seat positioning strap is an option on this wheelchair (you may order with or without the seat positioning strap), Invacare strongly recommends ordering the seat positioning strap as an additio...
      • With regards to seat/chest positioning straps - it is the obligation of the DME dealer, therapists and other healthcare professionals to determine if a seat/chest positioning strap is required to ensure the safe operation of this equipment by the use...
      • Stability
        • m
    • Warning
      • The back height, front caster position, caster size, seat-to-floor angle, position of the rear wheels, correct anti-tipper as well as the end user's disability or end user's physical condition and capabilities directly relate to the stability of the ...
      • Seat-to-floor heights have specific positions depending on rear wheel size, rear wheel position, front caster position and seat-to-floor angle. These adjustments must be performed by a qualified technician.
        • back height
        • caster position
        • caster size
        • seat-to-floor angle
        • wheel position
        • user condition
        • Anti-tippers
    • Tire Pressure
      • m
    • Warning
      • DO NOT use your wheelchair unless it has the proper tire pressure (p.s.i.). DO NOT overinflate the tires. Failure to follow these suggestions may cause the tire to explode and cause bodily harm. The recommended tire pressure is on the sidewall of the...
    • Weight Limitation
      • m
    • Warning
      • Weight limitation is 700 lbs. Weight limitation with heavy duty frame is 1,000 lbs.
    • Weight Training
      • m
    • Warning
      • Invacare does not recommend the use of its wheelchairs as a weight training apparatus. Invacare wheelchairs have not been designed or tested as a seat for any kind of weight training. If occupant uses said wheelchair as a weight training apparatus, I...
    • Wheel Locks
      • m
    • Warning
      • DO NOT attempt to stop a moving wheelchair with wheel locks. Wheel locks are not brakes.
      • If the wheelchair is equipped with push to lock wheel locks, elevating legrests, and wheel lock extension handles, the wheel lock extension handles MUST be removed before swinging the elevating legrests to the side, otherwise injury or damage may res...
      • Engaging the wheel locks may not prevent the wheelchair from moving on all floor surfaces including those that may be wet or slick. ALWAYS exercise caution when transferring into or out of the wheelchair.
      • Wheelchair Tie Down Restraints
        • m
    • Warning
      • Invacare recommends that wheelchair users not be transported in vehicles of any kind while in wheelchairs. As of this date, the Department of Transportation has not approved any tie-down systems for transportation of a user while in a wheelchair, in ...
      • It is Invacare’s position that users of wheelchairs should be transferred into appropriate seating in vehicles for transportation and use be made of the restraints made available by the auto industry. Invacare cannot and does not recommend any whee...
      • Wheelchair User
        • m
    • Warning
      • As a manufacturer of wheelchairs, Invacare endeavors to supply a wide variety of wheelchairs to meet many needs of the end user. However, final selection of the type of wheelchair to be used by an individual rests solely with the user and his/her hea...
      • The intended use for this wheelchair is for the bariatric user.
  • 3.1 Safety/Handling of Wheelchairs
    • Safety and handling of the wheelchair requires the close attention of the wheelchair user as well as the assistant. This manual points out the most common procedures and techniques involved in the safe operation and maintenance of the wheelchair. It ...
    • Use this information only as a basic guide. The techniques that are discussed on the following pages have been used successfully by many.
    • Individual wheelchair users often develop skills to deal with daily living activities that may differ from those described in this manual. Invacare recognizes and encourages each individual to try what works best for him/her in overcoming architectur...
    • Stability and Balance
      • m
    • Warning
      • Be aware that carrying heavy objects on your lap while occupying the wheelchair may adversely affect the stability of the wheelchair, resulting in serious bodily injury to the user, damage to the wheelchair and surrounding property.
      • This wheelchair has been designed to accommodate one individual. If more than one individual occupies the wheelchair this may adversely affect the stability of the wheelchair, resulting in serious bodily injury to the user and passenger and damage to...
      • To assure stability and proper operation of your wheelchair, you must at all times wear your seat positioning strap and maintain proper balance. Your wheelchair has been designed to remain upright and stable during normal daily activities as long as ...
      • Virtually all activities which involve movement in the wheelchair have an effect on the center of gravity. Invacare recommends using seat/chest positioning straps for additional safety while involved in activities that shift your weight.
      • DO NOT lean forward out of the wheelchair any further than the length of the armrests. Make sure the casters are pointing in the forward position whenever you lean forward. This can be achieved by advancing the wheelchair and then reversing it in a s...
      • Many activities require the wheelchair user to reach, bend and transfer in and out of the wheelchair. These movements will cause a change to normal balance, center of gravity, and weight distribution of the wheelchair.
      • To determine and establish your particular safety limits, practice bending, reaching and transferring activities in several combinations in the presence of a qualified healthcare professional before attempting active use of the wheelchair.
      • Proper positioning is essential for your safety. When reaching, leaning, bending forward, it is important to use the front casters as a tool to maintain stability and balance.
    • Reaching, Leaning and Bending
      • m
    • Warning
      • DO NOT shift your weight or sitting position toward direction you are reaching as the wheelchair may tip over.
      • DO NOT attempt to reach objects if you have pick them up from the floor by reaching down between your knees.
      • DO NOT lean over the top of the back upholstery to reach objects behind you, as this may cause the wheelchair to tip over.
        • Forward
        • Backward
          • FIGURE 1 Reaching, Leaning and Bending
    • Coping With Everyday Obstacles
      • Coping with the irritation of everyday obstacles can be alleviated somewhat by learning how to manage your wheelchair. Keep in mind your center of gravity to maintain stability and balance.
    • Tipping
      • m
    • WARNING
      • DO NOT tip the wheelchair when occupied to traverse curbs or other such obstructions. Always use curb cuts. Otherwise, injury or damage may result.
    • Stairways
      • m
    • WARNING
      • Extreme caution is advised when it is necessary to move an unoccupied wheelchair up or down the stairs. Invacare recommends using two assistants and making thorough preparations. Make sure to use only secure, non-detachable parts for hand-hold supports.
      • DO NOT attempt to lift the wheelchair by any removable (detachable) parts. Lifting by means of any removable (detachable) parts of a wheelchair may result in injury to the user or damage to the wheelchair.
      • Follow this procedure for moving the wheelchair between floors when an elevator is NOT available:
    • Moving Up Stairs
      • 1. Remove the occupant from the wheelchair.
      • 2. If necessary, rotate the anti-tippers so the wheels are facing up.
      • 3. One assistant (positioned behind the wheelchair), securely grasps a non-removable (non-detachable) part of the wheelchair for leverage and tilts the wheelchair back to the balance point.
      • 4. After the wheelchair has been tilted back to the balance point, the assistant behind the wheelchair backs the wheelchair up against the first step.
      • 5. The second assistant (positioned in the front of the wheelchair), with a firm hold on a non-detachable part of the framework, lifts the wheelchair up and on to the next stair above and steadies the wheelchair as the assistant behind the wheelchair...
      • 6. The wheelchair should not be lowered until the last stair has been negotiated and the wheelchair has been rolled away from the stairway.
      • 7. If necessary, rotate the anti-tippers so the wheels are facing down.
    • Moving Down Stairs
      • 1. Remove the occupant from the wheelchair.
      • 2. If necessary, rotate the anti-tippers so the wheels are facing up.
      • 3. One assistant (positioned behind the wheelchair), securely grasps a non-removable (non-detachable) part of the wheelchair for leverage and tilts the wheelchair back to the balance point.
        • 4. After the wheelchair has been tilted back to the balance point, the assistant behind the wheelchair rolls the wheelchair up to the edge of the first step.
        • 5. The second assistant (positioned in the front of the wheelchair), with a firm hold on a non-detachable part of the framework, lowers the wheelchair down and on to the next stair below and steadies the wheelchair as the assistant in the rear places...
        • 6. The wheelchair should not be lowered until the last stair has been negotiated and the wheelchair has been rolled away from the stairway.
        • 7. If necessary, rotate the anti-tippers so the wheels are facing down.
        • FIGURE 2 Stairways
    • Escalators
      • m
    • WARNING
      • DO NOT use an escalator to move a wheelchair between floors. Serious bodily injury may occur.
    • Transferring To and From Other Seats
      • m
    • WARNING
      • Before attempting to transfer in or out of the wheelchair, every precaution should be taken to reduce the gap distance. Turn both casters parallel to the object you are transferring onto. Also be certain the wheel locks are engaged to help prevent th...
    • caution
      • When transferring, position yourself as far back as possible in the seat. This will help prevent damaged upholstery and the possibility of the wheelchair tipping forward.